ISSN print edition: 0366-6352 ISSN electronic edition: 1336-9075 Registr. No.: MK SR 9/7 Published monthly

Transport of iron ions from chloride solutions using cellulose triacetate matrix inclusion membranes with an ionic liquid carrier

Monika Baczynska, Martyna Rzelewska, Magdalena Regel-Rosocka, and Maciej Wisniewski

Institute of Chemical Technology and Engineering, Faculty of Chemical Technology, Poznan University of Technology, Berdychowo St. 4, 60-965 Poznan, Poland

E-mail: magdalena.regel-rosocka@put.poznan.pl

Abstract: In this study, liquid membranes denoted as polymer inclusion membranes (PIMs) consisting of cellulose triacetate (CTA) as a polymer matrix, o-nitrophenyl octyl ether (NPOE) as a plasticiser and phosphonium ionic liquids, trihexyltetradecylphosphonium chloride (Cyphos^® IL 101) and trihexyltetradecylphosphonium bis(2,4,4-trimethylpentyl)phosphinate (Cyphos^® IL 104), as carriers of metal ions were developed. The transport of Fe(II) and Fe(III) from chloride aqueous solutions across PIMs was investigated. It is shown that these phosphonium ionic liquids are effective carriers of Fe(III) ions through PIMs.While, for Fe(II), the highest value of extraction efficiency and recovery factor after 72 h does not exceed 40 %, by contrast, the values of these parameters for Fe(III) transport ranged from 60 % to almost 100 %. Additionally, the results indicate the transport rate to be strongly influenced by the amount of carrier in the membrane. The highest initial flux of Fe(III) and permeability coefficient are noted for the membrane containing 40 mass % Cyphos^® IL 101. However, it is shown that the transport of Fe(III) increases as the carrier content is increased then decreases at a content of the carrier equal to 40 mass %. It appears that the Fe(III)-carrier complex decomposes with difficulty at the interface of the membrane-receiving phase, hence leading to low values of recovery factor Fe(III).

Keywords: iron(II) – iron(III) – metal ion extraction – ionic liquid – polymer inclusion membrane – CTA matrix

Full paper is available at www.springerlink.com.

DOI: 10.1515/chempap-2015-0198

Chemical Papers 70 (2) 172–179 (2016)